STECO CORP -- TAP MAGIC ORIGINAL CUTTING FLUID -- 9150-01-373-5788 
=====================  Product Identification  =====================

Product ID:TAP MAGIC ORIGINAL CUTTING FLUID
MSDS Date:03/31/1989
FSC:9150
NIIN:01-373-5788
=== Responsible Party ===
Company Name:STECO CORP
Address:2330 CANTRELL ROAD
Box:2238
City:LITTLE ROCK
State:AR
ZIP:72203-2238
Country:US
Info Phone Num:800-255-3924/800-643-8026
Emergency Phone Num:800-255-3924/800-643-8026
CAGE:17781
=== Contractor Identification ===
Company Name:INDUSTRIAL SUPPLY CORP
Address:1905 WESTWOOD AVE
Box:6356
City:RICHMOND
State:VA
ZIP:23230
Country:US
Phone:804-355-8041
CAGE:6A908
Company Name:STECO CORP
Address:2330 CANTRELL ROAD
Box:2238
City:LITTLE ROCK
State:AR
ZIP:72203
Country:US
Phone:800-643-8026
CAGE:17781

=============  Composition/Information on Ingredients  =============

Ingred Name:1,1,1 TRICHLOROETHANE
CAS:71-55-6
RTECS #:KJ2975000
Fraction by Wt: 90%
Other REC Limits:NONE RECOMMENDED
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ozone Depleting Chemical:1

Ingred Name:TERT-BUTYL ALCOHOL (SARA 313)
CAS:75-65-0
RTECS #:EO1925000
Fraction by Wt: 3%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM
ACGIH TLV:100 PPM;  9495

Ingred Name:1,2-BUTYLENE OXIDE
CAS:106-88-7
RTECS #:EK3675000
Fraction by Wt: 3%
Other REC Limits:NONE RECOMMENDED
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB

Ingred Name:METHYLAL (DIMETHOXYMETHANE)
CAS:109-87-5
RTECS #:PA8750000
Fraction by Wt: 3%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM

Ingred Name:PETROLEUM OIL, ALAPHATIC
CAS:68815-10-1
Fraction by Wt: 3%
Other REC Limits:NONE RECOMMENDED

Ingred Name:CINNAMALDEHYDE
CAS:104-55-2
RTECS #:GD6475000
Fraction by Wt: 3%
Other REC Limits:NONE RECOMMENDED

=====================  Hazards Identification  =====================

LD50 LC50 Mixture:ORAL LD50 (RAT) IS  >10,000 MG/KG
Routes of Entry: Inhalation:YES  Skin:YES  Ingestion:YES
Reports of Carcinogenicity:NTP:NO    IARC:NO	OSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION-MINIMAL ANESTHETIC
    OR NARCOTIC EFFECTS MAY BE SEEN IN THE RANGE 500-1000 PPM. THSES
    HIGH LEVELS MAY ALSO CAUSE CARDIAC ARRHYTHMIAS. INGESTION-IF
    ASPIRATED, MAY RESULT IN INJURY TO OT HER BODY SYSTEMS. EYE-MAY
    CAUSE IRRITATION. CHRONIC: SKIN- DEFATTING OF SKIN, IRRITATION.
Explanation of Carcinogenicity:DOES NOT CAUSE CANCER IN LONG TERM
    ANIMAL STUDIES. NOT A CARCINOGENIC OR SUSPECT CARCINOGEN.
Effects of Overexposure:INHALATION-CAUSES DIZZINESS, DRUNKENNESS,
    UNCONSCIOUSNESS AND DEATH. SKIN-RASH. EYE-MAY CAUSE PAIN
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

=======================  First Aid Measures  =======================

First Aid:EYE-FLUSH GENTLY WITH WATER FOR 15 MIN SUPPORTIVE TREATMENT
    IS RECOMMENDED BY PHYSICIAN. SKIN-WASH WITH MILD SOAP & WATER.
    INHALATION-REMOVE TO FRESH AIR. MAY REQUIRE ARTIFICIAL RESPIRATION
    & OXYGEN.  EPINEPHRINE & OTHER DRUGS WITH SIMILIARACTIVITY SHOULD
    NOT BE ADMINISTERED. INGESTION-DO NOT INDUCE VOMITING. CALL A
    PHYSICIA &/OR TRANSPORT TO EMERGENCY FACILITY IMMEDIATELY.

=====================  Fire Fighting Measures  =====================

Flash Point Method:TOC
Flash Point:NONE
Autoignition Temp:Autoignition Temp Text:NONE
Lower Limits:6
Upper Limits:16.7
Extinguishing Media:WATER FOG.
Fire Fighting Procedures:POSITIVE PRESSURE SELF-CONTAINED RESPIRATORY
    EQUIPMENT.
Unusual Fire/Explosion Hazard:PRODUCT DOES NOT PRESENT ANY FIRE HAZARD,
    HOWEVER WHEN CONCENTRATED VAPORS ARE EXPOSED TO OPEN FLAMES,
    IRRITATING & TOXIC GASES (HCL) MAY BE FORMED.

==================  Accidental Release Measures  ==================

Spill Release Procedures:SMALL SPILL: MOP UP, WIPE UP OR SOAK UP
    IMMEDIATELY. REMOVE TO OUT-OF-DOORS.
Neutralizing Agent:PRODUCT MAY BE EFFECTIVELY ABSORBED WITH ACTIVATED
    CHARCOAL.

======================	Handling and Storage  ======================

Handling and Storage Precautions:IDEALLY, A COOL, DRY, WELL VENTILATED
    STORAGE AREA SHOULD BE SELECTED, HOWEVER, A PROPERLY SEALED
    CONTAINER MAY BE STORED UNDER HIGHER AMBIENT TEMPS.
Other Precautions:USE WITH ADEQUATE VENTILATION. AVOID PROLONGED OR
    REPEATED BREATHING OF VAPORS. CONCENTRATED VAPORS ARE HEAVIER THAN
    AIR AND WILL COLLECT IN LOW AREAS SUCH AS PITS, STORAGE TANKS AND
    OTHER CONFINED AR EAS.

=============  Exposure Controls/Personal Protection  =============

Respiratory Protection:NONE DURING NORMAL USE. WHEN RESPIRATORY
    PROTECTION IS REQUIRED FOR CERTAIN OPERATIONS, USE AN APPROVED AIR
    PURIFYING RESPIRATOR. FOR EMERGENCY CONDITIONS, USE AN APPROVED
    POSITIVE PRESSURE SELF-CONTA INED BREATHING APPARATUS.
Ventilation:NORMAL VENTILATION WITH REGULAR USE TO MAINTAIN THE TLV
    BELOW RECOMMENDED VALUES (350 PPM).
Protective Gloves:SYNTHETIC RUBBER GLOVES.
Eye Protection:SINGLE SAFETY GLASSES TO CUP-TYPE GOGGLE
Other Protective Equipment:SYNTHETIC RUBBER APRONS AND COVERALLS MAY BE
    NECESSARY TO PREVENT EXCESSIVE SKIN CONTACT WHEN DEALING WITH LARGE
    SPILLS.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
DO NOT TAKE INTERNALLY. LARGE AMOUNTS CAN DISPLACE OXYGEN IN CONFINED
    AREAS. AVOID PROLONGED OR REPEATED CONTACT WITH SKIN. UN DIVISION
    6.1.

==================  Physical/Chemical Properties  ==================

HCC:T4
Boiling Pt:B.P. Text:158-190F
Vapor Pres:100
Vapor Density:4.55
Spec Gravity:1.36
Evaporation Rate & Reference:0.5 GAL/SQ FT/DAY
Solubility in Water:0.07% BY WEIGHT
Appearance and Odor:AMBER LIQUID, NON-AQUEOUS, AROMATIC ODOR.
Percent Volatiles by Volume:>90

=================  Stability and Reactivity Data  =================

Stability Indicator/Materials to Avoid:YES
MAGNESIUM & ALUMINUM, POLYSTYRENE, CELLULOSE ACETATE, PROPIONATE &
    POLYCARBONATE PLASTICS, ASPHALT, RUBBER, BUNA RUBBER.
Stability Condition to Avoid:PROLONGED STORAGE IN CONTACT WITH WATER
    MAY CAUSE SOME DECOMPOSITION & FORMATION OF HYDROCHLORIC ACID.
    (TEMPS >150F)
Hazardous Decomposition Products:WHEN EXPOSED TO OPEN FLAMES OR HIGH
    ENERGY ARC, PRODUCT MAY DECOMPOSE YIELDING HYDROGEN CHLORIDE GAS.

====================  Disposal Considerations  ====================

Waste Disposal Methods:VERY SMALL AMOUNTS MAY BE EVAPORATED IN
    COMPLIANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS INCLUDING
    SUBTITLE C OF THE RESOURCE CONSERVATION AND RECOVERY ACT.

 Disclaimer (provided with this information by the compiling agencies):
 This information is formulated for use by elements of the Department
 of Defense.  The United States of America in no manner whatsoever,
 expressly or implied, warrants this information to be accurate and
 disclaims all liability for its use.  Any person utilizing this
 document should seek competent professional advice to verify and
 assume responsibility for the suitability of this information to their
 particular situation.