|
|
|
| (000000-000000- - 5438) |
Date of Issue:
8/4/2005 12:00:00 AM |
|
Supercedes:
4/17/2003 12:00:00 AM |
Chemical Name &
Synonyms:
N/A |
|
Trade Name &
Synonyms:
DRI-LUBE
PLUS AEROSOL |
Chemical Family:
ALCOHOL MIXTURE
|
|
Formula is a
mixture: [√] |
Manufacturer Name:
CERTIFIED LABS, DIV. OF NCH
CORP. |
|
|
Manufacturer
Address:
BOX 152170
IRVING, TEXAS 75015
|
|
|
Prepared By:
M McDowell/Chemist |
Product Code Number:
5438 |
Emergency Phone
Number:
800-424-9300 | |
| THE HAZARDS PRESENTED BELOW ARE THOSE OF THE
INDIVIDUAL COMPONENTS |
| |
| |
| |
|
|
|
| Boiling Point (°F): |
180°
|
Specific Gravity
(H20=1): |
0.817
|
| Vapor Pressure (mm Hg): |
1323.4
|
Color: |
DARK GRAY
|
| Vapor Density (Air=1): |
1.9
|
Odor: |
ALCOHOL |
| pH @ 100% : |
N/A |
Clarity: |
OPAQUE
|
| % Volatile by Volume: |
99
|
Evaporation Rate (BuAc=1): |
51.5
|
| H20 Solubility: |
NEGLIGIBLE
|
Viscosity: |
SLIGHT VISCOUS
|
| |
|
|
| |
| Flash Point: |
47°F |
Method Used: |
SETAFLASH
|
| Flammable Limits: |
PRODUCT MIXTURE
|
UEL: |
12.7
|
| LEL: |
1.8
|
Aerosol Level (NFPA
30B): |
3 | |
|
|
| Special Fire Fighting
Procedures: FIREFIGHTERS SHOULD
WEAR A SELF-CONTAINED BREATHING APPARATUS AND FULL PROTECTIVE
GEAR. COOL FIRE-EXPOSED CONTAINERS WITH WATER SPRAY TO PREVENT
BURSTING. |
| Unusual Fire and Explosion
Hazards: VAPORS ARE HEAVIER
THAN AIR AND MAY TRAVEL TO DISTANT AND/OR LOW-LYING SOURCES OF
IGNITION AND FLASHBACK. PRODUCT MAY PRODUCE A FLOATING FIRE
HAZARD AS LIQUID FLOATS ON WATER. FLAME EXTENSION IS >36
INCHES, BURNBACK IS 6 INCHES.
| |
Threshold
Limit Value:
NOT ESTABLISHED FOR
MIXTURE. SEE SECTION II. |
| Effects
of Overexposure: |
Acute: (Short Term
Exposure)
EYE CONTACT: CAUSES
IRRITATION SEEN AS STINGING, TEARING, BLURRED VISION,
SWELLING, A BURNING SENSATION, AND REDNESS. PROLONGED CONTACT
MAY CAUSE CORNEAL DAMAGE. SKIN CONTACT: MAY CAUSE IRRITATION
SEEN AS ITCHING AND REDNESS. PROLONGED OR REPEATED CONTACT AS
FROM CLOTHING WET WITH MATERIAL MAY CAUSE DRYING, DEFATTING,
AND CRACKING OF THE SKIN. PRODUCT MAY BE ABSORBED THROUGH THE
SKIN IN HARMFUL AMOUNTS. INHALATION: CAUSES RESPIRATORY
IRRITATION SEEN AS COUGHING AND SNEEZING. AT LOW VAPOR
CONCENTRATIONS, NO HARMFUL EFFECTS ARE EXPECTED. AT HIGH VAPOR
CONCENTRATIONS, INHALATION MAY CAUSE CENTRAL NERVOUS SYSTEM
EFFECTS SUCH AS HEADACHE, DIZZINESS, DROWSINESS, WEAKNESS,
UNCONCIOUSNESS, POSSIBLE ANESTHETIC EFFECTS FROM CENTRAL
NERVOUS SYSTEM DEPRESSION, AND MAY BE FATAL. INGESTION: MAY
CAUSE IRRITATION WITH POSSIBLE NAUSEA, VOMITING, AND DIARRHEA.
INGESTION AND SUBSEQUENT VOMITING OF THIS PRODUCT CAN LEAD TO
ASPIRATION OF THE PRODUCT INTO THE LUNGS WHICH CAN CAUSE
DAMAGE AND MAY BE FATAL. MAY CAUSE CENTRAL NERVOUS SYSTEM
EFFECTS SIMILAR TO INHALATION. |
Chronic: (Long Term
Exposure)
ON RARE OCCASIONS,
PROLONGED AND REPEATED EXPOSURE TO HYDROCARBON MIST POSES A
RISK OF CHRONIC LUNG INFLAMMATION. THIS CONDITION IS USUALLY
ASYMPTOMATIC AS A RESULT OF REPEATED SMALL ASPIRATIONS.
SHORTNESS OF BREATH AND COUGHING ARE THE MOST COMMON SYMPTOMS.
ASPIRATION MAY LEAD TO PULMONARY EDEMA AND HEMORRHAGE AND MAY
BE FATAL. SIGNS OF LUNG INVOLVEMENT INCLUDE INCREASED
RESPIRATION AND HEART RATES AS WELL AS A BLUISH DISCOLORATION
OF THE SKIN. CHRONIC SKIN CONTACT MAY PROMOTE DERMATITIS AND
OIL ACNE. IN RARER CASES, AN INCREASED SENSTIVITY TO SUNLIGHT
(PHOTOSENSITIVITY) MAY OCCUR. MEDICAL CONDITIONS AGGRAVATED BY
EXPOSURE ARE PRE-EXISTING RESPIRATORY AND SKIN CONDITIONS SUCH
AS ASTHMA, EMPHYSEMA, AND DERMATITIS. TARGET ORGANS: CENTRAL
NERVOUS SYSTEM. THE PRIMARY ROUTES OF EXPOSURE ARE SKIN AND
EYE CONTACT. |
|
| Emergency
First Aid Procedures: |
Inhalation:
REMOVE FROM THE
AREA TO FRESH AIR. SEEK MEDICAL ATTENTION IF RESPIRATORY
IRRITATION DEVELOPS OR IF BREATHING BECOMES
DIFFICULT. |
Eye Contact:
RINSE THE EYES WITH
WATER. REMOVE ANY CONTACT LENSES AND CONTINUE FLUSHING WITH
PLENTY OF WATER FOR SEVERAL MINUTES. SEEK MEDICAL ATTENTION IF
IRRITATION DEVELOPS. |
Skin Contact:
WASH AFFECTED AREAS
WITH PLENTY OF SOAP AND WATER FOR SEVERAL MINUTES. SEEK
MEDICAL ATTENTION IF IRRITATION DEVELOPS. |
Ingestion:
GIVE 3 TO 4 GLASSES
OF WATER, BUT DO NOT INDUCE VOMITING. IF VOMITING OCCURS, GIVE
FLUIDS AGAIN. GET IMMEDIATE MEDICAL ATTENTION. DO NOT GIVE
ANYTHING BY MOUTH TO AN UNCONSCIOUS OR CONVULSING
PERSON. |
Notes to Physician:
INGESTION AND
SUBSEQUENT VOMITING OF THIS PRODUCT CAN LEAD TO ASPIRATION OF
THE PRODUCT INTO THE LUNGS WHICH CAN CAUSE DAMAGE AND MAY BE
FATAL. DEPENDING ON THE AMOUNT INGESTED AND RETAINED AS WELL
AS THE TOXICITY OF THE PRODUCT, GASTRIC LAVAGE SHOULD BE
CONSIDERED. KEEP PATIENT'S HEAD BELOW HIPS TO PREVENT
PULMONARY ASPIRATION. IF COMATOSE, A CUFFED ENDOTRACHAEL TUBE
WILL PREVENT
ASPIRATION. | |
|
|
VOC CONTENT: 95% BY
WEIGHT, 98.7% BY VOLUME, 672.4 G/L
ISOPROPANOL
ORL-HMN LDLo: 3570 MG/KG 3.
ORL-RAT LD50: 5045 MG/KG
3.
IHL-RAT LC50: 16000 PPM/8H 3.
SKN-RBT LD50: 12800
MG/KG 3.
SKN-RBT SDT: 500 MG MILD 3.
EYE-RBT SDT: 10 MG
MODERATE 3.
MOLYBDENUM DISULFIDE
ORL-RAT LD50: >2
GM/KG 3.
ORL-RAT LDLo: 6 GM/KG 3.
IHL-RAT LC50: >2820
MG/M3/4H 3.
SKN-RAT LD50: >2 GM/KG 3.
AROMATIC
PETROLEUM DISTILLATES
ORL-RAT LD50: 8400 MG/KG
3.
IHL-RAT TCLO: 1320 PPM/6H/90D-I 3.
EYE-RBT SDT: 100
UL/24H MILD 3.
HYDROCARBON MISTS DERIVED FROM PETROLEUM
DISTILLATES ARE REPORTED TO HAVE LOW ACUTE AND SUB-ACUTE
TOXICITIES IN ANIMALS. EFFECTS FROM SINGLE AND SHORT-TERM
REPEATED EXPOSURES TO HIGH CONCENTRATIONS WELL ABOVE
APPLICABLE WORKPLACE EXPOSURE LEVELS INCLUDE LUNG INFLAMMATORY
REACTION, LIPOID GRANULOMA FORMATION, AND LIPOID PNEUMONIA. IN
ACUTE AND SUB-ACUTE STUDIES INVOLVING EXPOSURES TO LOWER
CONCENTRATIONS AT OR NEAR CURRENT WORK PLACE EXPOSURE LEVELS
PRODUCED NO SIGNIFICANT TOXICOLOGICAL EFFECTS. IN LONG TERM
STUDIES (UP TO TWO YEARS) NO CARCINOGENIC EFFECTS HAVE BEEN
REPORTED IN ANY ANIMAL SPECIES TESTED. THESE PETROLEUM
DISTILLATES ARE SEVERELY HYDROTREATED, SEVERELY SOLVENT
EXTRACTED, AND/OR PROCESSED BY MILD HYDROTREATMENT AND
EXTRACTION. FOR THIS REASON, THEY ARE NOT CLASSIFIED AS CANCER
HAZARDS. 4.
PROPANE
IHL-LC50 >40% BY VOLUME
4.
ISOBUTANE
IHL-RAT LC50: 658 G/M3/4H
3.
HUMAN VOLUNTEERS EXPOSED REPEATEDLY TO GASES OF
SIMILAR HYDROCARON MIXTURES RANGING FROM 250 TO 1000 PPM
EXHIBITED NO CARDIAC OR PULMONARY FUNCTION ABNORMALITIES.
4.
ETHYLCELLULOSE
ORL-RAT LD50: >5 GM/KG
3.
SKN-RBT LD50: >5 GM/KG 3.
SKN-RBT SDT: 500 MG/24H
MILD 3. | |
|
|
Incompatibility (Materials to
Avoid):
STRONG OXIDIZING
AGENTS SUCH AS CHLORINE BLEACH AND CONCENTRATED HYDROGEN
PEROXIDE, ACIDS, CAUSTICS, CHLORINATED COMPOUNDS, HALOGENS,
AMINES, ALKANOLAMINES AND ALDEHYDES. |
Hazardous Decomposition
Products:
OXIDES OF CARBON,
SULFUR, AND MOLYBDENUM. | |
Steps to be Taken if Material is
Released or Spilled:
DUE TO THE NATURE
OF THE AEROSOL PACKAGING, A LARGE SPILL IS UNLIKELY. FOR A
SMALL SPILL, WEAR APPROPRIATE PROTECTIVE CLOTHING, VENTILATE
THE AREA, ABSORB WITH AN INERT MATERIAL AND TRANSFER ALL
MATERIAL INTO A PROPERLY LABELED CONTAINER FOR DISPOSAL. USE
CARE AS SPILLS MAY BE SLIPPERY. |
Waste Disposal
Method(s):
DISPOSE OF IN
ACCORDANCE WITH ALL FEDERAL, STATE, AND LOCAL REGULATIONS.
TYPICAL DISPOSAL IS TO WRAP THE EMPTY AEROSOL CONTAINER IN
SEVERAL LAYERS OF NEWSPAPER AND DISPOSE OF IN THE TRASH.
AEROSOL RECYCLING PROGRAMS ARE AVAILABLE IN MANY AREAS. DO NOT
PUNCTURE OR INCINERATE THIS CONTAINER. |
Neutralizing Agent:
N/A | |
Required
Ventilation:
LOCAL VENTILATION
IS RECOMMENDED TO CONTROL EXPOSURE FROM OPERATIONS THAT CAN
GENERATE EXCESSIVE LEVELS OF MISTS AND VAPORS. LOCAL
VENTILATION IS PREFERRED, BECAUSE IT PREVENTS DISPERSION INTO
WORK AREAS BY CONTROLLING IT AT ITS SOURCE. |
Respiratory
Protection:
RESPIRATORS SHOULD
BE SELECTED BY AND USED UNDER THE DIRECTION OF A TRAINED
HEALTH AND SAFETY PROFESSIONAL FOLLOWING REQUIREMENTS FOUND IN
OSHA'S RESPIRATOR STANDARD (29 CFR 1910.134) AND ANSI'S
STANDARD FOR RESPIRATORY PROTECTION (Z88.2-1992). FOR
CONCENTRATIONS ABOVE THE TLV AND/OR PEL BUT LESS THAN 10 TIMES
THESE LIMITS, A NIOSH APPROVED HALF-FACEPIECE RESPIRATOR
EQUIPPED WITH APPROPRIATE CHEMICAL CARTRIDGES MAY BE USED. FOR
CONCENTRATIONS GREATER THAN 10 TIMES THE TLV AND/OR PEL,
CONSULT THE NIOSH RESPIRATOR DECISION LOGIC FOUND IN
PUBLICATION NO. 87-116 OR ANSI Z88.2-1992. |
Glove Protection:
NEOPRENE OR NITRILE
RUBBER GLOVES IF REPEATED OR PROLONGED SKIN CONTACT IS LIKELY.
ENSURE COMPLIANCE WITH OSHA'S PERSONAL PROTECTIVE EQUIPMENT
(PPE) STANDARD FOR HAND PROTECTION, 29 CFR
1910.138. |
Eye Protection:
SAFETY GLASSES WITH
SIDE SHIELDS IF THE METHOD OF USE PRESENTS THE LIKELIHOOD OF
EYE CONTACT. ENSURE COMPLIANCE WITH OSHA'S PERSONAL PROTECTIVE
EQUIPMENT (PPE) STANDARD FOR EYE AND FACE PROTECTION, 29 CFR
1910.133. |
Other Protection:
WEAR GENERAL-DUTY
WORK CLOTHES AND SHOES. A SAFETY SHOWER AND AN EYEWASH STATION
SHOULD BE AVAILABLE. REMOVE SOAKED CLOTHING AND SHOES. WASH
CLOTHING AND CLEAN SHOES BEFORE
REUSE. | |
Section X -
Storage and Handling Information
|
|
|
Precautions to be Taken in Handling
and Storing:
USE WITH CAUTION
AROUND HEAT, SPARKS, PILOT LIGHTS, STATIC ELECTRICITY, AND
OPEN FLAME. |
Other Precautions:
KEEP OUT OF REACH
OF CHILDREN. READ THE ENTIRE LABEL BEFORE USING THE PRODUCT.
FOLLOW THE LABEL
DIRECTIONS. | |
|
| |
| Those
Ingredients listed above are subject to the reporting
requirements of 313 of Title III of the Superfund Amendments
and Reauthorization Act of 1986 and 40 CFR part
372. |
| |
| Please call
1-800-527-9919 for additional information if you are a
California customer. This MSDS is not intended for users in
the state of California. |
|
|
|
|
| 1. THRESHOLD
LIMIT VALUES FOR CHEMICAL SUBSTANCES AND PHYSICAL AGENTS
AND BIOLOGICAL EXPOSURE INDICES, ACGIH, 2005. 2. OSHA
PEL. 3. REGISTRY OF TOXIC EFFECTS OF CHEMICAL
SUBSTANCES, CCINFOWeb, 2005. 4. VENDOR'S MSDS. ALL THE
COMPONENTS OF THIS PRODUCT ARE IN COMPLIANCE WITH THE
TOXIC SUBSTANCES CONTROL ACT (TSCA) AND ARE EITHER
LISTED ON THE TSCA INVENTORY OR OTHERWISE EXEMPTED FROM
LISTING. - IRR:IRRITANT, FLAM/FLAMM:FLAMMABLE,
COMB:COMBUSTIBLE, CORR:CORROSIVE CARC:CARCINOGENIC,
TOX:TOXIC, N/A:NOT APPLICABLE, N/E:NOT ESTABLISHED,
COC:CLEVELAND OPEN CUP, PMCC:PENSKY-MARTIN CLOSED CUP,
TCC:TAGLIABUE CLOSED CUP, LEL:LOWER EXPLOSION LIMIT,
UEL:UPPER EXPLOSION LIMIT, NFPA:NATIONAL FIRE PROTECTION
ASSOCIATION, IARC:INTERNATIONAL AGENCY FOR THE RESEARCH
ON CANCER, NTP:NATIONAL TOXICOLOGY PROGRAM,
OSHA:OCCUPATIONAL SAFETY & HEALTH ADMINISTRATION,
ACGIH:AMERICAN CONFERENCE OF GOVERNMENTAL INDUSTRIAL
HYGIENISTS, TLV:THRESHOLD LIMIT VALUE, PEL:PERMISSIBLE
EXPOSURE LIMIT, STEL:SHORT-TERM EXPOSURE LIMIT,
MLD:MILD, MOD:MODERATE, SEV:SEVERE, MUT:MUTAGENIC,
ASPHYX:ASPHYXIANT, PNOS:PARTICLES (INSOLUBLE) NOT
OTHERWISE SPECIFIED, SDT:STANDARD DRAIZE TEST, ORL:ORAL,
IHL:INHALATION, HMN:HUMAN |
|
| |
| | |
|